Surfactant replacement therapy in combination with different non-invasive ventilation techniques in spontaneously-breathing, surfactant-depleted adult rabbits

Abstract

Nasal intermittent positive pressure ventilation (NIPPV) holds great potential as a primary ventilation support method for Respiratory Distress Syndrome (RDS). The use of NIPPV may also be of great value combined with minimally invasive surfactant delivery. Our aim was to implement an in vivo model of RDS, which can be managed with different non-invasive ventilation (NIV) strategies, including non-synchronized NIPPV, synchronized NIPPV (SNIPPV), and nasal continuous positive airway pressure (NCPAP). Forty-two surfactant-depleted adult rabbits were allocated in six different groups: three groups of animals were treated with only NIV for three hours (NIPPV, SNIPPV, and NCPAP groups), while three other groups were treated with surfactant (SF) followed by NIV (NIPPV+SF, SNIPPV+SF, and NCPAP+SF groups). Arterial gas exchange, ventilation indices, and dynamic compliance were assessed. Post-mortem the lungs were sampled for histological evaluation. Surfactant depletion was successfully achieved by repeated broncho-alveolar lavages (BALs). After BALs, all animals developed a moderate respiratory distress, which could not be reverted by merely applying NIV. Conversely, surfactant administration followed by NIV induced a rapid improvement of arterial oxygenation in all surfactant-treated groups. Breath synchronization was associated with a significantly better response in terms of gas exchange and dynamic compliance compared to non-synchronized NIPPV, showing also the lowest injury scores after histological assessment. The proposed in vivo model of surfactant deficiency was successfully managed with NCPAP, NIPPV, or SNIPPV; this model resembles a moderate respiratory distress and it is suitable for the preclinical testing of less invasive surfactant administration techniques.

About the Authors:

Francesca Ricci

Roles Conceptualization, Data curation, Formal analysis, Investigation, Methodology, Project administration, Supervision, Validation, Visualization, Writing – original draft, Writing – review & editing

Affiliation: Chiesi Farmaceutici, R&D Department, Parma, Italy

Costanza Casiraghi

Roles Conceptualization, Data curation, Formal analysis, Investigation, Methodology, Project administration, Supervision, Validation, Writing – original draft, Writing – review & editing

* E-mail: [email protected]

Affiliation: Chiesi Farmaceutici, R&D Department, Parma, Italy

ORCID logo http://orcid.org/0000-0001-6225-5250

Matteo Storti

Roles Conceptualization, Data curation, Formal analysis, Investigation, Methodology, Validation, Writing – original draft

Affiliation: Chiesi Farmaceutici, R&D Department, Parma, Italy

Francesco D’Alò

Roles Conceptualization, Data curation, Formal analysis, Investigation, Methodology, Validation, Visualization

Affiliation: Chiesi Farmaceutici, R&D Department, Parma, Italy

Chiara Catozzi

Roles Conceptualization, Data curation, Formal analysis, Investigation, Methodology, Validation, Visualization

Affiliation: Chiesi Farmaceutici, R&D Department, Parma, Italy

Roberta Ciccimarra

Roles Formal analysis, Investigation, Methodology

Affiliation: Department of Veterinary Science, University of Parma, Parma, Italy

Francesca Ravanetti

Roles Conceptualization, Data curation, Formal analysis, Investigation, Methodology, Supervision, Visualization, Writing – original draft, Writing – review & editing

Affiliation: Department of Veterinary Science, University of Parma, Parma, Italy

Antonio Cacchioli

Roles Data curation, Formal analysis, Methodology, Supervision, Writing – original draft, Writing – review & editing

Affiliation: Department of Veterinary Science, University of Parma, Parma, Italy

Gino Villetti

Roles Conceptualization, Methodology, Project administration, Supervision, Validation, Writing – original draft, Writing – review & editing

Affiliation: Chiesi Farmaceutici, R&D Department, Parma, Italy

Maurizio Civelli

Roles Conceptualization, Methodology, Supervision, Validation, Writing – original draft

Affiliation: Chiesi Farmaceutici, R&D Department, Parma, Italy

Xabi Murgia

Roles Conceptualization, Data curation, Formal analysis, Investigation, Methodology, Visualization, Writing – original draft, Writing – review & editing

Affiliation: Department of Drug Delivery, Helmholtz Institute for Pharmaceutical Research Saarland, Saarbrücken, Germany

Virgilio Carnielli

Roles Conceptualization, Supervision, Validation, Writing – original draft, Writing – review & editing

Affiliation: Division of Neonatology, Polytechnic University of Marche and Salesi Children’s Hospital, Ancona, Italy

Fabrizio Salomone

Roles Conceptualization, Data curation, Formal analysis, Investigation, Methodology, Project administration, Supervision, Validation, Visualization, Writing – original draft, Writing – review & editing

Affiliation: Chiesi Farmaceutici, R&D Department, Parma, Italy

Introduction

Preterm birth is characterized by a marked immaturity of all organ systems. In very preterm infants, the signs of lung immaturity manifest shortly after birth. Alveolar instability, arising from the incapacity of the underdeveloped alveolar epithelium to synthesize and secrete adequate quantity of surfactant [1,2], leads to alveolar collapse, which in turn compromises the vital systemic oxygen delivery and, ultimately, the life of infants who suffer the so called respiratory distress syndrome (RDS).

RDS infants routinely require artificial respiratory support and surfactant replacement therapy [3,4]. The classic treatment against RDS entailed early tracheal intubation of the infants followed by the intratracheal instillation of exogenous surfactant and a variable period of intensive mechanical ventilation [5,6]. Although this approach has proved to be a life-saving therapy, the association between mechanical ventilation through an endotracheal tube and the incidence of chronic lung disease [7–9] led to the search of alternative, non-invasive ventilation (NIV) strategies.

Nasal continuous positive airway pressure (NCPAP) has been the earliest form of non-invasive respiratory support [10,11]. Its use as a first line treatment against RDS (without surfactant treatment) has become nowadays standard clinical practice [3,12]. However, despite its efficacy, this technique cannot always avoid tracheal intubation, particularly for very low-gestational-age preterm infants [13,14]. Nasal intermittent positive pressure ventilation (NIPPV) is an enhanced form of NCPAP, which superimposes a pre-set number of mandatory “breaths” to the background NCPAP [15]. Moreover, it is possible to synchronize the mandatory “breaths” provided by the ventilator with the spontaneous breathing efforts of the infant, as in synchronized NIPPV (SNIPPV) [16]. Breath synchronization further improves pulmonary mechanics, reduces the work of breathing, and enhances gas exchange [17].

A limitation regarding the universal application of NIV to all preterm infants is that newborns with moderate to severe RDS will be inadequately supported by NIV, ultimately requiring intubation and surfactant therapy at a later stage [18]. The solution to avoid the failure of NIV is the timely administration of exogenous surfactant. Recently, successful approaches of less invasive surfactant administration have been described, consisting of delivering an intratracheal bolus of surfactant through a thin tube, while infants are managed with NCPAP [19,20]. Surfactant aerosol delivery in combination with NCPAP has been investigated as the ideal, non-invasive alternative which holds the potential to couple NIV with surfactant replacement [21–26]. Nevertheless, the technical challenge of delivering medical aerosols to neonates is high [27] and needs further preclinical development, including appropriate in vivo experiments with models that can be managed with NIV.

In a previous study, we have implemented and fully characterized the spontaneously-breathing, lung-lavaged adult rabbit as an in vivo model of respiratory distress which can be managed with NCPAP [28]. Interestingly, this model showed a significant improvement of the pulmonary status if surfactant therapy was applied in combination with NCPAP compared to NCPAP only. In the present study, our primary aim was to address the feasibility of implementing this model with alternative techniques of NIV such as NIPPV and SNIPPV. In addition, we hypothesized that the use of NIPPV or SNIPPV could improve the pulmonary outcomes after surfactant treatment compared to NCPAP.

Materials and methods

Animal handling and surfactant delivery protocol

The experiments were carried out in 6- to 7-week-old rabbits. The experimental procedure was approved by the intramural Animal Welfare Body and the Italian Ministry of Health (Prot.n° 1300-2015-PR) and complied with the European and Italian regulations for animal care.

Rabbits (body weight of 1.5–2.5 kg) were initially sedated with intramuscular (i.m.) medetomidine (Domitor®, 2 mg/kg) and handled as previously described [28]. Briefly, the throat of the animals was first shaved and local anaesthesia was applied in the anterior neck with lidocaine gel (Luan® 2.5%). Thirty minutes later the animals received 50 mg/kg of ketamine (Imalgene 1000®, Merial-Boehringer Ingelheim, France) and 5 mg/kg of xylazine (Rompun®, Bayer, Germany) i.m. Rabbits, in supine position, were intubated and stabilized on positive pressure ventilation (Fabian HFO, Acutronic, Zug, Switzerland) with the following settings: FiO2 = 100%, Flow = 10 L/min, respiratory rate (RR) = 40 breaths/min, positive end-expiratory pressure (PEEP) = 3 cmH2O, tidal volume (VT) targeted to 7 ml/kg (with the peak inspiratory pressure, PIP, not exceeding 15 cmH2O) and inspiratory time of 0.5 sec. Airway flow, mean airway pressure (MAP) and VT were monitored with a flow sensor connected to the endotracheal tube, as long as the animals were intubated. Body temperature was monitored with a rectal probe and it was maintained by placing a heating pad underneath the animal.

After endotracheal intubation, a catheter was inserted into the right jugular vein for continuous infusion of 1 mg/ml of ketamine and 0.1 mg/ml of xylazine (100 μl/min). Trometamol (tris-hydroxymethyl aminomethane, THAM, 1M, Sigma-Aldrich, USA) was also infused during the surfactant depletion procedure. A second catheter was inserted into the right carotid artery for blood sampling. After instrumentation, the baseline blood gases were measured with an emogas analyzer (Radiometer Medical, Denmark).

If the initial inclusion criteria of arterial oxygen partial pressure (PaO2) value > 400 mmHg at PIP < 15 cmH2O were met, the animal was included in the study. Repeated broncho-alveolar lavages (BALs) were performed by flushing the airways with 20 ml/kg of pre-warmed (37°C) 0.9% NaCl solution, followed by a short recovery period in-between, until a PaO2 value < 100 mmHg was reached. Then, if after 15 min of stabilization on mechanical ventilation the respiratory failure was confirmed (PaO2 < 100 mmHg, with PIP not exceeding 23 cmH2O), the animal was allocated in one of the study groups. NIV support was applied using nasal prongs (Fisher & Paykel, Auckland, New Zealand). Just before extubation, the animals assigned to the surfactant + NIV groups received a bolus of 200 mg/kg of surfactant (SF, Curosurf, Chiesi Farmaceutici, Parma, Italy).

Animals included in the NCPAP (n = 6) and NCPAP+SF (n = 6) groups were maintained in NCPAP (5 cmH2O, Fabian HFO, Acutronic, Zug, Switzerland) for 180 minutes, as previously described [28].

The animals included in the NIPPV (n = 8) and NIPPV+SF (n = 7) groups were managed with non-synchronized NIPPV (Fabian HFO, Acutronic, Zug, Switzerland) for 180 min. The initial settings of NIPPV support were: PIP = 21–23 cmH2O, PEEP 5 cmH2O, RR (guaranteed) = 60 breaths/min, inspiratory time = 0.5.

The SNIPPV (n = 7) and SNIPPV+SF (n = 8) groups were managed with SNIPPV using the Sophie ventilator (Fritz Stephan GmbH, Gackenbach, Germany) with the Graseby abdominal capsule-triggering device (Fritz Stephan GmbH, Gackenbach, Germany) for breath synchronization. Briefly, this system detects the diaphragmatic mechanical perturbations induced by the animals’ respiratory effort, which are then converted into a stable, fast-reacting (<30 ms) trigger signal. The initial settings of SNIPPV support were: PIP = 20 cmH2O, PEEP 5 cmH2O, RR (guaranteed) = 60 breaths/min, inspiratory time = 0.5.

Gas exchange

Arterial carbon dioxide partial pressure (PaCO2) and PaO2 were measured right after the induction of the anaesthesia (baseline), after inducing the respiratory failure by repeated BALs, and after the stabilization period following the insult to confirm the respiratory failure (Radiometer Medical, Denmark). Arterial blood gases were also measured right after placing the animals on NIV support, 15 and 30 min after the start of NIV support, and then every 30 min until the end of the experiment.

Ventilation indices

The ventilation efficacy index (VEI) and the Oxygenation index (OI) were calculated at baseline, after surfactant depletion by repeated BALs, and at the end of the observational period. Once the observational period was completed, animals were shifted from NIV to invasive mechanical ventilation for a brief period of time, with the same settings used at baseline (before the BALs: FiO2 100%, Flow = 10 L/min; RR = 40 bpm, PEEP = 3 cmH2O, VT targeted to 7 ml/kg, and inspiratory time of 0.5).

VEI was calculated to evaluate the overall ventilation efficiency of mechanically ventilated animals independently from the ventilation settings, as follows:

OI was calculated to quantify the severity of pulmonary dysfunction in ventilated animals:

Lung mechanics

Dynamic compliance (Cdyn) was determined in all animals at baseline, after BAL-induced surfactant depletion, and again at the end of the follow-up period, after re-intubation. Cdyn was calculated by dividing the changes in lung volume (ΔV) by the changes in pressure (ΔP) multiplied by the weight of the animal in Kg. ΔV and ΔP were obtained by spirometry (Acutronic).

Histological analysis

The right lung was sampled in the cranial, middle and caudal lobes to represent non-dependent, intermediate and dependent lung regions. The samples were fixed in 10% neutral buffered formalin, then dehydrated in graded alcohol solutions, xylene clarified, paraffin infiltrated by means of an automatic processor (ATP 700 Tissue Processor, Histo-line laboratories, Italy), and embedded with the dorsal surface of the slice down (EG 1160, Leica Biosystems, Mannheim, Germany). Sections, 5 μm thick, were obtained using a rotary microtome (Slee Cut 6062, Slee Medical, Mainz, Germany). Three slides for each lung region were then further deparaffinized, rehydrated in descending grades of ethanol, and finally stained with hematoxylin and eosin (Sigma). Images of the samples were acquired at 40X magnification by a digital slide scanner (NanoZoomer, Hamamatsu, Hamamatsu City, Japan). Lung injury was scored by an investigator blinded to the experimental design using a semi-quantitative scoring system [29,30]. All parenchyma within a histological slide was scored considering multiple and not overlapping ROIs at 10X magnification. According to internal standard procedure, the ROIs occupied for more than 30% in area by conductive airways or blood vessels were excluded. Alveolar and interstitial inflammation, alveolar and interstitial hemorrhage, edema, and atelectasis were each scored on a 0 to 4 point scale. Each ROI was scored as 0 if the item was absent or normal, as 1 if the item was present in 25% of the field, as 2 if it was present in 50% of the field, as 3 if it was present in 75% of the field and as 4 if the item was apparent throughout the whole field. The total injury score was calculated as a sum of these scores and the average of the ROIs was reported for each section.

Statistical analysis

Physiological parameters are presented as mean ± SEM. Raw data were analyzed and compared by repeated measures two-way analysis of variance (ANOVA) as a function of group and time or one-way ANOVA, followed by Tukey’s post-hoc test. The data of the histological score are presented as mean ± SEM and analysed by the non-parametric Kruskal-Wallis test. Statistical analysis was performed using GraphPad software, version 7.0.

Results

The body weight of the animals, the PaO2 and the Cdyn at baseline and the number of BALs needed to achieve respiratory failure were not significantly different between the groups (Table 1). BALs led to a marked (P<0.0001) decrease of PaO2 and Cdyn values, indicative of a dramatic reduction of the alveolar surfactant pool [28].

[Figure omitted. See PDF.]

Table 1. Body weight, number of BALs, and baseline as well as post-BALs (respiratory failure) values of PaO2 and Cdyn in adult rabbits included in the study.

https://doi.org/10.1371/journal.pone.0200542.t001

Gas exchange

After surfactant depletion, all groups showed mean PaO2 values below 80 mmHg, even though the FiO2 was set to 100%. As expected, PaO2 values increased in all SF-treated groups immediately after SF instillation (Fig 1). In particular, PaO2 values were back to the basal levels (before BALs) after 60 minutes in the SNIPPV+SF group and after 120 minutes in the NCPAP+SF group. Arterial oxygenation was clearly superior in SF-treated animals throughout the follow up period. Among SF-treated groups, the highest mean PaO2 values were observed for the SNIPPV+SF group, which were significantly higher compared to NIPPV+SF at any time-point. The mean PaO2 values of the NCPAP+SF group were higher than the values observed for NIPPV, reaching statistical significance at 60 and 120 minutes.

[Figure omitted. See PDF.]

Fig 1. Mean PaO2 values over time of surfactant-depleted rabbits managed with non-invasive ventilation.

Surfactant-depleted adult rabbits were treated with nasal continuous positive pressure ventilation (NCPAP, white diamonds), with NCPAP + intratracheal surfactant (NCPAP+SF, black diamonds), with nasal non-synchronized intermittent positive ventilation (NIPPV, white squares), with NIPPV + intratracheal surfactant (NIPPV+SF, black squares), with Synchronized Intermittent Positive Pressure Ventilation (SNIPPV, white circles), or with SNIPPV + intratracheal surfactant (SNIPPV+SF, black circles). Surfactant-treated animals (black symbols) received a bolus of surfactant before extubation, immediately after the 0 time-point. Values are shown as the mean ± SEM. * P vs. NIPPV+SF group < 0.01; # P vs. SNIPPV group < 0.01; § P vs. NCPAP group < 0.01; & P vs. NIPPV group < 0.01.

https://doi.org/10.1371/journal.pone.0200542.g001

The mean PaCO2 values increased in all groups due to the respiratory failure induced by the BALs. Even though a slight downward trend of the mean PaCO2 values could be observed within the first 30 min in the SF-treated groups, the arterial carbon dioxide levels remained rather high in all groups, without significant differences in the first two hours of the follow up period. The worst PaCO2 values were observed in the NCPAP group; in the last hour of the follow up the mean PaCO2 of the NCPAP group was over 100 mmHg, significantly higher compared to NIPPV and NIPPV+SF groups at 150 minutes and to all the other groups at 180 minutes (Fig 2).

[Figure omitted. See PDF.]

Fig 2. Mean PaCO2 values over time of surfactant-depleted rabbits managed with non-invasive ventilation.

Surfactant-depleted adult rabbits were treated with NCPAP only (white diamonds), with NCPAP+SF (black diamonds), with NIPPV only (white squares), with NIPPV+SF (black squares), with SNIPPV only (white circles), or with SNIPPV+SF (black circles). Surfactant-treated animals (black symbols) received a bolus of surfactant before extubation, immediately after the 0 time-point. Values are shown as the mean ± SEM * P vs. NIPPV group < 0.01; # P vs. NIPPV+SF group < 0.01; § P vs. all other groups < 0.01.

https://doi.org/10.1371/journal.pone.0200542.g002

Ventilation indices

To directly compare the pulmonary status of the animals before and after treatment, at the end of NIV follow-up period, all animals were re-intubated and mechanically ventilated with the same ventilation settings as at baseline (before the BALs). The OI and the VEI were therefore calculated for the time-points in which the animals were managed with invasive mechanical ventilation: 1) at baseline, 2) after surfactant depletions by repeated BALs, and 3) at the end of the experiment (180 minutes).

The mean OI at baseline was below 1.4 in all groups, indicative of an optimal pulmonary oxygen exchange. However, surfactant depletion by repeated BALs induced a significant respiratory failure which increased the OI in all animals, yielding a mean value of 19.2 ± 7.6, considering all the animals featured in the study. The tested NIV techniques without SF treatment could not restore the OI to baseline values; moreover, the pulmonary response to the different NIV modalities without surfactant treatment was not uniform within the groups showing a great intra-group variability (Fig 3A). At the end of the experimental period, the mean OI values of the NIPPV, SNIPPV and NCPAP groups were 12.98 ± 4.27 (range 2.46–35.9), 15.17 ± 3.7 (1.76–33.22), and 16.61 ± 2.88 (3.37–22.59), respectively. Surfactant therapy in combination with NIV, however, was associated with a significantly better OI score compared with NIV alone. The combined use of surfactant and SNIPPV or NCPAP could revert the high mean OI values observed after the BALs to baseline values; in addition, it is noteworthy that the pulmonary response to the combined treatment in these two groups was remarkably homogeneous: the mean OI values for the SNIPPV+SF and NCPAP+SF groups were 1.35 ± 0.04 (range 1.15–1.46) and 1.91 ± 0.22 (1.24–2.84), respectively. Surfactant therapy followed by non-synchronized NIPPV also improved the OI significantly compared to animal groups treated with NIV only. Nevertheless, the mean OI of the NIPPV+SF group was slightly higher (4.29 ± 1.18, range 1.57–10.42) than in the SNIPPV+SF and NCPAP+SF groups.

[Figure omitted. See PDF.]

Fig 3. The oxygenation index (OI) and the ventilation efficacy index (VEI) of surfactant-depleted rabbits managed with non-invasive ventilation.

To the left of the dashed line, the baseline and post-surfactant depletion OI (A) and VEI (B) values of all the animals featured in the study are given. To the right of the dashed line, the OI and VEI values of the different groups after 180 minutes of management with NIV are shown. Surfactant-treated groups are represented by the box-plots with a grey filling, whereas the groups treated with NIV only are represented by the white box-plots. The small squares within each box-plot indicate the mean of the group. The whiskers indicate the maximum and minimum values observed for each group. * P < 0.01 vs. any group not treated with surfactant; # P < 0.01 vs. SNIPPV+SF group. NCPAP: nasal continuous positive airway pressure, SF: surfactant, NIPPV: nasal (non-synchronized) intermittent positive pressure ventilation, and SNIPPV: synchronized NIPPV.

https://doi.org/10.1371/journal.pone.0200542.g003

The VEI was markedly influenced by the elevated PaCO2 values observed in all groups (Fig 3B). The mean VEI for all the animals at baseline, before the induction of the respiratory failure, was 0.25 ± 0.001, indicative of normal ventilation. The VEI dropped dramatically after the BALs to 0.01 ± 0.001 (P<0.001), as expected. At the end of the experiment the highest mean VEI values were achieved by the SNIPPV+SF group (0.17 ± 0.03), which were in turn significantly higher than those achieved by the SNIPPV (0.06 ± 0.01), NCPAP (0.06 ± 0.01), NIPPV+SF (0.08 ± 0.02), and NCPAP+SF (0.10 ± 0.02) groups (P<0.01).

Lung mechanics

Cdyn values were assessed at those time intervals in which the animals were ventilated with invasive positive pressure ventilation. Cdyn was equivalent for all groups at baseline (NIPPV, 1.11 ± 0.1 mL/cmH2O/kg; NIPPV+SF, 1.05 ± 0.06 mL/cmH2O/kg, SNIPPV, 0.82 ± 0.02 mL/cmH2O/kg; SNIPPV+SF, 0.90 ± 0.1 mL/cmH2O/kg; NCPAP, 0.94 ± 0.06 mL/cmH2O/kg; NCPAP+SF, 0.88 ± 0.07 1.11 ± 0.1 mL/cmH2O/kg). However, Cdyn dropped dramatically after surfactant depletion to a mean value of 0.36 ± 0.02 mL/cmH2O/kg. After three hours of follow-up, mean Cdyn values increased in all surfactant-treated groups (Fig 4). The highest mean Cdyn value was observed for the SNIPPV+SF group (0.80 ± 0.17 mL/cmH2O/kg), which was significantly higher compared to NIPPV+SF, SNIPPV and NCPAP groups (P<0.01). In the animal groups treated with NIV only, the mean Cdyn values remained low in the SNIPPV and NCPAP groups (0.36 ± 0.08 and 0.37 ± 0.07 mL/cmH2O/kg, respectively) and slightly increased in the NIPPV group (0.53 ± 0.07 mL/cmH2O/kg).

[Figure omitted. See PDF.]

Fig 4. Dynamic compliance (Cdyn) of surfactant-depleted rabbits managed with non-invasive ventilation.

To the left of the dashed line, the baseline and post-surfactant depletion Cdyn values of all the animals featured in the study are given. To the right of the dashed line, the Cdyn values of the different groups after 180 minutes of management with NIV are shown. Surfactant-treated groups are represented by the box-plots with a grey filling, whereas the groups merely treated with NIV are represented by the white box-plots. The small squares within each box-plot indicate the mean of the group. The whiskers indicate the maximum and minimum values observed for each group. # P < 0.01 vs. SNIPPV+SF group. NCPAP: nasal continuous positive airway pressure, SF: surfactant, NIPPV: nasal (non-synchronized) intermittent positive pressure ventilation, and SNIPPV: synchronized NIPPV.

https://doi.org/10.1371/journal.pone.0200542.g004

Histological analysis

The histological examination of the lungs showed a marked inflammatory interstitial and alveolar neutrophilic infiltration, alveolar and interstitial haemorrhage, thickening of the alveolar wall, and accumulation of proteinaceous oedema and atelectasis: these findings are typical features of an acute inflammation (examples in S1 Fig). From the overall view of the samples, surfactant-treated groups showed a moderate decrease of the neutrophil infiltrates and of the haemorrhagic areas both in the alveolar space and interstitium compared to their reference groups treated with NIV only (Fig 5 and Table 2).

[Figure omitted. See PDF.]

Fig 5. Histological microphotographs of surfactant-depleted rabbits managed with non-invasive ventilation.

Histological overview of lung parenchyma presenting representative inflammatory infiltrate, hemorrhage, edema and atelectasis for all groups. SF: surfactant; NCPAP: nasal continuous positive airway pressure (A,B); NIPPV: nasal intermittent positive pressure ventilation (C,D); SNIPPV: synchronized NIPPV (E,F). Haematoxylin & Eosin staining, scale bar 250 μm.

https://doi.org/10.1371/journal.pone.0200542.g005

[Figure omitted. See PDF.]

Table 2. Histological scores of surfactant-depleted adult rabbits.

https://doi.org/10.1371/journal.pone.0200542.t002

The sum score for SNIPPV+ SF and NCPAP+SF groups was significantly lower compared to the SNIPPV and NCPAP groups, respectively. Among surfactant-treated groups, SNIPPV+SF and NCPAP+SF performed significantly better than NIPPV+SF. Indeed, the SNIPPV+SF group had the lowest scores among all groups.

Irrespective of whether surfactant was administered or not, synchronization of the animal’s breathing pattern and the ventilator’s drive during nasal intermittent ventilation was associated with significantly better histological outcomes.

Discussion

In the present study, we have successfully implemented an in vivo model of surfactant depletion induced by repeated BALs, which can be managed with different NIV techniques, including NCPAP, NIPPV, and SNIPPV. As evidenced by the marked drop of arterial oxygenation and Cdyn, the respiratory distress induced to the animals after lung lavage was severe enough to preclude the full pulmonary recovery by merely applying NIV. However, early surfactant instillation followed by any of the tested NIV techniques was associated with a significant improvement of the arterial oxygenation. It is worth mentioning that the combined treatment of early surfactant followed by SNIPPV was found to maximize the initial response to surfactant therapy, achieving a rapid and uniform recovery of the baseline PaO2 values, a significant improvement of the VEI, a marked increase of the Cdyn, and the best histological outcomes among all groups.

The use of NCPAP without surfactant treatment has become a standard clinical practice for the treatment of mild-to-moderate RDS [3,12,18]. Moreover, nasal ventilation has demonstrated great clinical value not only in preventing extubation failures [31,32] and as a treatment of apnea of prematurity [33], but also as a first line treatment against RDS [34,35]. Unfortunately, in many cases the application of NIV alone is not enough to adequately support RDS infants, particularly those born before the 28th week of gestation, in which the NCPAP failure fraction stands at approximately 40–50% [18]. In the present study, neither NCPAP, NIPPV nor SNIPPV alone could revert the respiratory failure induced after BALs, which indicates a marked depletion of the surfactant pool with the applied lung lavage protocol [28]. Irrespective of the ventilation modality, arterial oxygenation remained low in all groups treated with NIV only. The histological scores were as well significantly worse in the NIV only treated groups compared the ones observed in their equivalent SF-treated groups. Of note, the mean PaCO2 of the NCPAP group, at the end of the follow-up period, was significantly higher compared to the groups ventilated with intermittent positive pressure. We attribute this difference to the higher capacity of NIPPV and SNIPPV to flush the CO2 from the airways.

The results from this study suggest that, in the setting of a more severe RDS, early surfactant followed by NIV, avoiding intratracheal intubation, might represent the most effective therapeutic approach. Several attempts have been made to deliver a dose of surfactant without intubation. Surfactant aerosol delivery was developed with the aim to administer surfactant in combination with NIV. The safety and the efficacy of this approach were investigated in small clinical studies [23–26]. Although the therapy was proven to be safe, the clinical efficacy of this technique is not yet convincing [36]. Surfactant administration using the laryngeal mask airway has also been investigated as a less invasive surfactant administration method [37]. Recently, a minimally invasive way of surfactant administration has been successfully implemented in preterm infants: this technique consists of delivering an intratracheal bolus of surfactant through a thin tube, while the infants are supported with NCPAP [19,20]. This approach reduces the need for mechanical ventilation, supplemental oxygen, and NCPAP. Most of the aforementioned less invasive surfactant administration techniques used NCPAP immediately after surfactant delivery. The use of NCPAP following surfactant instillation was also associated with a rapid and uniform improvement of oxygenation in our in vivo model. However, the results obtained in this study bring up the following scientific question: should SNIPPV rather than NCPAP be used as a primary non-invasive respiratory support immediately after surfactant administration? The available clinical evidence remains controversial. Chen at al. did not find any statistical differences in the rate of endotracheal ventilation in twin pairs receiving surfactant and supported with either NCPAP or NIPPV [38]. Nevertheless, they found a marginal statistically significant difference favouring the use of NIPPV in infants with a gestational age of 32–33 weeks. Of note, the study by Chen et al. did not use breath-synchronization. Gizzi et al. compared the chart data of 31 infants undergoing the InSurE (Intubate-Surfactant-Extubate) approach supported with NCPAP with the data of 33 infants undergoing InSurE but supported with SNIPPV [39]. In this single-centre study, the use of SNIPPV significantly reduced the InSurE failure (2/33 in the SNIPPV group vs. 11/31 in the NCPAP group, P < 0.004) and the need for mechanical ventilation. These clinical studies suggest that the use of nasal ventilation might be of advantage compared to NCPAP after SF administration. In particular breath-synchronization has the potential to maximize SF-therapy and the overall pulmonary ventilation. For instance, during non-synchronized NIPPV, effective patient-ventilator synchronization has been described to occur only in 25% of the cycles [40]. The remaining asynchronous cycles are delivered by the ventilator at all phases of the infant’s respiratory cycle, including the early-, mid- and late-expiration [41]. This mismatch alters the spontaneous respiratory rhythm, induces glottal narrowing, increases the work of breathing (WOB), and can ultimately cause volutrauma [41]. Conversely, during SNIPPV, the positive pressure is delivered by the ventilator with the opened glottis and is therefore effectively transmitted to the lungs, reducing the thoraco-abdominal asynchrony, the inspiratory effort, and the WOB, yielding an improved pulmonary ventilation [17].

In the present study, the most prominent pulmonary improvement among all SF-treated groups, as well as the lowest lung injury scores, were also observed when SNIPPV was applied right after surfactant instillation. Therefore, this study is in line with the clinical reports that found a benefit in synchronizing the ventilator’s drive with the patient’s spontaneous breathing efforts. To achieve an efficient synchronization, we used the Graseby abdominal pneumatic capsule; this device has shown to correctly detect inspiration 88% of the times [42]. Compared to non-synchronized NIPPV, the use of SNIPPV immediately after surfactant instillation was associated with significantly better PaO2, VEI, and Cdyn values. In addition, the SNIPPV+SF group had a significantly lower injury score compared to the NIPPV+SF group and showed the best outcomes for all the studied items (inflammation, hemorrhage, edema, atelectasis) among all the study groups. We speculate that the coordinated “breaths” delivered by the ventilator during SNIPPV might have helped spreading the surfactant immediately after instillation, accounting for a better initial pulmonary distribution of surfactant that led to a rapid increase of the PaO2, a significant improvement of the VEI, and a better histological assessment.

We acknowledge that the present in vivo study has several limitations: on the one hand, the surfactant-depleted adult rabbit does not completely resemble the complex pathogenesis of RDS, which takes places in a significantly larger time-scale compared to the relatively short follow-up of our protocol. On the other hand, PaCO2 values remained above physiological levels in all groups, irrespective of the applied treatment. We assume that the high PaCO2 levels are due to the increased resistance to air flow of the customized nasal cannulas, which have been originally designed for humans and not for rabbits. Nevertheless, we have implemented an in vivo model of surfactant deficiency that can be alternatively managed with NCPAP, NIPPV, or SNIPPV; this model resembles a moderate respiratory distress, which cannot be reverted by merely applying NIV support. Conversely, surfactant administration followed by NIV was associated with a rapid improvement of arterial oxygenation, making this model suitable for the preclinical testing of alternative surfactant delivery methods, e.g. surfactant nebulization and laryngeal mask surfactant administration [37,43]. The present study also suggests that SNIPPV applied immediately after surfactant instillation may maximize the effects of surfactant therapy compared to other NIV modalities.

Supporting information

[Figure omitted. See PDF.]

S1 Fig. Examples of histological findings in surfactant-depleted rabbits managed with non-invasive ventilation.

Histological examples of lung parenchyma presenting inflammatory infiltrate, hemorrhage, edema and atelectasis. Haematoxylin & Eosin staining.

https://doi.org/10.1371/journal.pone.0200542.s001

(PDF)

Citation: Ricci F, Casiraghi C, Storti M, D’Alò F, Catozzi C, Ciccimarra R, et al. (2018) Surfactant replacement therapy in combination with different non-invasive ventilation techniques in spontaneously-breathing, surfactant-depleted adult rabbits. PLoS ONE 13(7): e0200542. https://doi.org/10.1371/journal.pone.0200542

References

1. Nkadi PO, Merritt TA, Pillers D- AM. An Overview of Pulmonary Surfactant in the Neonate: Genetics, Metabolism, and the Role of Surfactant in Health and Disease. Mol Genet Metab. 2009;97: 95–101. pmid:19299177

2. Zimmermann LJI, Janssen DJMT, Tibboel D, Hamvas A, Carnielli VP. Surfactant Metabolism in the Neonate. Neonatology. 2005;87: 296–307.

3. Sweet DG, Carnielli V, Greisen G, Hallman M, Ozek E, Plavka R, et al. European Consensus Guidelines on the Management of Respiratory Distress Syndrome—2016 Update. Neonatology. 2016; 107–125. pmid:27649091

4. Walsh BK, Daigle B, DiBlasi RM, Restrepo RD. AARC Clinical Practice Guideline. Surfactant Replacement Therapy: 2013. Respir Care. 2013;58: 367 LP–375.

5. Speer CP, Robertson B, Curstedt T, Halliday HL, Compagnone D, Gefeller O, et al. Randomized European multicenter trial of surfactant replacement therapy for severe neonatal respiratory distress syndrome: single versus multiple doses of Curosurf. Pediatrics. 1992;89: 13–20. pmid:1727997

6. Morley CJ, Greenough A, Miller NG, Bangham AD, Pool J, Wood S, et al. Randomized trial of artificial surfactant (ALEC) given at birth to babies from 23 to 34 weeks gestation. Early Hum Dev. 1988;17: 41–54. pmid:3061771

7. Hayes D, Feola DJ, Murphy BS, Shook LA, Ballard HO. Pathogenesis of bronchopulmonary dysplasia. Respiration. 2010. pp. 425–436. pmid:19786727

8. Northway WHJ, Rosan RC, Porter DY. Pulmonary disease following respirator therapy of hyaline-membrane disease: Bronchopulmonary dysplasia. N Engl J Med. 1967;276: 357–368. pmid:5334613

9. Jobe AH, Bancalari E. Bronchopulmonary Dysplasia. Am J Respir Crit Care Med. American Thoracic Society—AJRCCM; 2001;163: 1723–1729. pmid:11401896

10. Kattwinkel J, Nearman HS, Fanaroff AA, Katona PG, Klaus MH. Apnea of prematurity: Comparative therapeutic effects of cutaneous stimulation and nasal continuous positive airway pressure. J Pediatr. 1975;86: 588–592. pmid:1092821

11. Saunders R a, Milner a D, Hopkin IE. The effects of continuous positive airway pressure on lung mechanics and lung volumes in the neonate. Biol Neonate. 1976;29: 178–186. pmid:782570

12. Rojas-Reyes MX, Morley CJ, Soll R. Prophylactic versus selective use of surfactant in preventing morbidity and mortality in preterm infants. Cochrane database Syst Rev. 2012;3: CD000510.

13. Stoll BJ, Hansen NI, Bell EF, Shankaran S, Laptook AR, Walsh MC, et al. Neonatal outcomes of extremely preterm infants from the NICHD Neonatal Research Network. Pediatrics. 2010;126: 443–56. pmid:20732945

14. Dunn MS, Kaempf J, de Klerk A, de Klerk R, Reilly M, Howard D, et al. Randomized Trial Comparing 3 Approaches to the Initial Respiratory Management of Preterm Neonates. Pediatrics. 2011;128: e1069 LP–e1076.

15. Davis Peter G; Morley Colin J; Manley BJ. Noninvasive Respiratory Support: An Alternative to Mechanical Ventilation in Preterm Infants. In: Polin Richard A; Bancalari E, editor. The Newborn Lung: Neonatology Questions and Controversies. 2nd ed. Elsevier; 2012. pp. 265–283.

16. Owen LS, Manley BJ. Nasal intermittent positive pressure ventilation in preterm infants: Equipment, evidence, and synchronization. Semin Fetal Neonatal Med. Elsevier; 2017;21: 146–153.

17. Moretti C, Gizzi C, Montecchia F, Barbàra CS, Midulla F, Sanchez-Luna M, et al. Synchronized Nasal Intermittent Positive Pressure Ventilation of the Newborn: Technical Issues and Clinical Results. Neonatology. 2016. pp. 359–365. pmid:27251453

18. Dargaville PA, Gerber A, Johansson S, De Paoli AG, Kamlin COF, Orsini F, et al. Incidence and Outcome of CPAP Failure in Preterm Infants. Pediatrics. 2016;138: e20153985–e20153985. pmid:27365307

19. Göpel W, Kribs A, Ziegler A, Laux R, Hoehn T, Wieg C, et al. Avoidance of mechanical ventilation by surfactant treatment of spontaneously breathing preterm infants (AMV): An open-label, randomised, controlled trial. Lancet. 2011;378: 1627–1634. pmid:21963186

20. Dargaville PA, Aiyappan A, Cornelius A, Williams C, De Paoli AG. Preliminary evaluation of a new technique of minimally invasive surfactant therapy. Arch Dis Child—Fetal Neonatal Ed. 2011;96: F243 LP–F248.

21. Walther FJ, Hernández-Juviel JM, Waring AJ. Aerosol delivery of synthetic lung surfactant. Longo M, editor. PeerJ. 2014;2: e403. https://doi.org/10.7717/peerj.403 pmid:24918030

22. Dijk PH, Heikamp A, Oetomo SB. Surfactant nebulisation prevents the adverse effects of surfactant therapy on blood pressure and cerebral blood flow in rabbits with severe respiratory failure. Intensive Care Med. 1997;23: 1077–1081. pmid:9407244

23. Arrøe M, Pedersen-Bjergaard L, Albertsen P, Bodé S, Greisen G, Jonsbo F, et al. Inhalation of aerosolized surfactant (Exosurf®) to neonates treated with nasal continuous positive airway pressure. 1998.

24. Jorch G, Hartl H, Roth B, Kribs A, Gortner L, Schaible T, et al. To the editor: Surfactant aerosol treatment of respiratory distress syndrome in spontaneously breathing premature infants. Pediatric Pulmonology. 1997. pp. 222–224.

25. Berggren E, Liljedahl M, Winbladh B, Andreasson B, Curstedt T, Robertson B, et al. Pilot study of nebulized surfactant therapy for neonatal respiratory distress syndrome. Acta Paediatr. 2000;89: 460–4. pmid:10830460

26. Finer NN, Merritt TA, Bernstein G, Job L, Mazela J, Segal R. An open label, pilot study of Aerosurf® combined with nCPAP to prevent RDS in preterm neonates. J Aerosol Med Pulm Drug Deliv. 2010;23: 303–309. pmid:20455772

27. Mazela J, Polin RA. Aerosol delivery to ventilated newborn infants: Historical challenges and new directions. European Journal of Pediatrics. 2011. pp. 433–444.

28. Ricci F, Catozzi C, Murgia X, Rosa B, Amidani D, Lorenzini L, et al. Physiological, Biochemical, and Biophysical Characterization of the Lung-Lavaged Spontaneously-Breathing Rabbit as a Model for Respiratory Distress Syndrome. PLoS One. 2017;12: e0169190. pmid:28060859

29. Mrozek JP, Smith KM, Bing DR, Meyers PA, Simonton SC, Connet JE, et al. Exogenous surfactant and partial liquid ventilation: Physiologic and pathologic effects. Am J Respir Crit Care Med. 1997;156: 1058–1065. pmid:9351603

30. Zimmermann AM, Roberts KD, Lampland AL, Meyers PA, Worwa CT, Plumm B, et al. Improved gas exchange and survival after KL-4 surfactant in newborn pigs with severe acute lung injury. Pediatr Pulmonol. 2010;45: 782–788. pmid:20597076

31. Barrington KJ, Bull D, Finer NN, Objective A. Randomized trial of nasal synchronized intermittent mandatory ventilation compared with continuous positive airway pressure after extubation of very low birth weight infants. Pediatrics. 2001;107: 638–641. pmid:11335736

32. Khalaf MN, Brodsky N, Hurley J, Bhandari V. A prospective randomized, controlled trial comparing synchronized nasal intermittent positive pressure ventilation versus nasal continuous positive airway pressure as modes of extubation. Pediatrics. 2001;108: 13–17. pmid:11433048

33. Lin CH, Wang ST, Lin YJ, Yeh TF. Efficacy of nasal intermittent positive pressure ventilation in treating apnea of prematurity. Pediatr Pulmonol. 1998;26: 349–353. pmid:9859905

34. Bhandari V, Gavino RG, Nedrelow JH, Pallela P, Salvador a, Ehrenkranz R a et al. A randomized controlled trial of synchronized nasal intermittent positive pressure ventilation in RDS. J Perinatol. 2007;27: 697–703. pmid:17703184

35. Sai Sunil Kishore M, Dutta S, Kumar P. Early nasal intermittent positive pressure ventilation versus continuous positive airway pressure for respiratory distress syndrome. Acta Paediatr. 2009;98: 1412–5. pmid:19523049

36. Mazela J, Merritt TA, Finer NN. Aerosolized surfactants. Curr Opin Pediatr. 2007;19: 155–162. pmid:17496758

37. Roberts KD, Lampland AL, Meyers PA, Worwa CT, Plumm BJ, Mammel MC. Laryngeal mask airway for surfactant administration in a newborn animal model. Pediatr Res. 2010;68: 414–418. pmid:20613684

38. Chen L, Wang L, Li J, Wang N, Shi Y. Noninvasive Ventilation for Preterm Twin Neonates with Respiratory Distress Syndrome: A Randomized Controlled Trial. Sci Rep. Nature Publishing Group; 2015;5: 14483. pmid:26399752

39. Gizzi C, Papoff P, Giordano I, Massenzi L, Barbàra CS, Campelli M, et al. Flow-Synchronized Nasal Intermittent Positive Pressure Ventilation for Infants <32 Weeks’ Gestation with Respiratory Distress Syndrome. Crit Care Res Pract. Hindawi Publishing Corporation; 2012;2012: 301818. pmid:23227317

40. Owen LS, Morley CJ, Dawson JA, Davis PG. Effects of non-synchronised nasal intermittent positive pressure ventilation on spontaneous breathing in preterm infants. Arch Dis Child—Fetal Neonatal Ed. 2011;96: F422 LP–F428.

41. Gizzi C, Montecchia F, Panetta V, Castellano C, Mariani C, Campelli M, et al. Is synchronised NIPPV more effective than NIPPV and NCPAP in treating apnoea of prematurity (AOP)? A randomised cross-over trial. Arch Dis Child—Fetal Neonatal Ed. 2015;100: F17 LP–F23.

42. Chang HY, Claure N, D’Ugard C, Torres J, Nwajei P, Bancalari E. Effects of synchronization during nasal ventilation in clinically stable preterm infants. Pediatr Res. 2011;69: 84–89. pmid:20924313

43. Hütten MC, Kuypers E, Ophelders DR, Nikiforou M, Jellema RK, Niemarkt HJ, et al. Nebulization of Poractant alfa via a vibrating membrane nebulizer in spontaneously breathing preterm lambs with binasal continuous positive pressure ventilation. Pediatr Res. 2015;78: 664–669. pmid:26322413