About the Authors:
Songlin Yu
Affiliation: Department of Clinical Laboratory, Peking Union Medical College Hospital, Chinese Academy of Medical Sciences, Beijing, 100730, China
Weiyan Zhou
Affiliation: Beijing Hospital National Center for Clinical Laboratories, Ministry of Health, Beijing, 100730, China
Xinqi Cheng
Affiliation: Department of Clinical Laboratory, Peking Union Medical College Hospital, Chinese Academy of Medical Sciences, Beijing, 100730, China
Huiling Fang
Affiliation: Department of Clinical Laboratory, Peking Union Medical College Hospital, Chinese Academy of Medical Sciences, Beijing, 100730, China
Ruiping Zhang
Affiliation: Department of Clinical Laboratory, China-Japan Friendship Hospital, Beijing, 100029, China
Qian Cheng
Affiliation: Department of Clinical Laboratory, Peking Union Medical College Hospital, Chinese Academy of Medical Sciences, Beijing, 100730, China
Jianhua Han
Affiliation: Department of Clinical Laboratory, Peking Union Medical College Hospital, Chinese Academy of Medical Sciences, Beijing, 100730, China
Wei Su
Affiliation: Department of Clinical Laboratory, Peking Union Medical College Hospital, Chinese Academy of Medical Sciences, Beijing, 100730, China
Liangyu Xia
Affiliation: Department of Clinical Laboratory, Peking Union Medical College Hospital, Chinese Academy of Medical Sciences, Beijing, 100730, China
Ling Qiu
* E-mail: [email protected]
Affiliation: Department of Clinical Laboratory, Peking Union Medical College Hospital, Chinese Academy of Medical Sciences, Beijing, 100730, China
Introduction
Siemens systems for 25-hydroxyvitamin D (25OHD) measurement are popular worldwide; however, in previous studies [1], an unexpected large bias was found when using the Siemens ADVIA Centaur XP system to measure 25OHD. This bias was related to use of VACUETTE® blood collection tubes with serum clot activator and gel [2]. The mechanism mediating this interference is unclear, and whether blood collection tubes from other manufacturers also affect 25OHD measurement by the Siemens ADVIA Centaur XP system is unknown.
Furthermore, in studies of vitamin D, serum may not be measured immediately after collection. Therefore, it is also necessary to evaluate the effects of storage temperature to confirm the accuracy of vitamin D results in stored samples. However, it is unclear whether temperature affects the results obtained using the Siemens ADVIA Centaur XP system.
Here, we investigated a number of popularly used blood collection tubes from other manufacturers and with storage temperatures to confirm whether these factors affect 25OHD detection by the Siemens ADVIA Centaur XP system (Siemens Healthcare Diagnostics [Shanghai], Walpole, NJ, USA).
Material and Methods
Participants, study design, and analysis
Twenty healthy volunteers were recruited, and fasting blood samples were collected by venipuncture into four types of venous blood collection tubes: 5-mL BD Vacutainer® SST tubes (REF: 366566, lot #4113190; BD, Franklin Lakes, NJ, USA); IMPROVEVACUTER® tubes with serum clot activator and gel (REF: U222538, lot #141014; IMPROVEMEDICAL, Guangzhou, China); VACUETTE® 4-mL no-additive tubes (REF: 454001, lot #A1405144; Greiner Bio-one, Kremsmunster, Austria); and VACUETTE® tubes with serum clot activator and gel (REF: 454067, lot #A130202D; Greiner Bio-one). To determine whether the clot activator or gel interfered with the Siemens system, we collected serum samples from another 16 volunteers into VACUETTE® 4-mL no-additive tubes, VACUETTE® tubes with serum clot activator and gel, and VACUETTE® tubes with clot activator but no gel (REF: 454204, lot #D140200Y; Greiner Bio-one).
The collected blood was centrifuged within 2 h (1200 × g, 10 min). The first aliquot was analyzed using the Siemens ADVIA Centaur Vitamin D Total kit (lot #39566029) on the Siemens ADVIA Centaur XP system according to the manufacturer’s instructions (IFU version: 10699313, 08/2012) and using a liquid chromatography tandem mass spectrometry (LC-MS/MS) method designed in our laboratory [2] immediately. The other two aliquots were separated into 2.0-mL cryovials (Corning Incorporated, USA) and analyzed after storage for 48 h at 4°C or -80°C.
This study was performed in accordance with the Code of Ethics of the World Medical Association (Declaration of Helsinki). All participants provided written consent for the use of their samples. This study was reviewed and approved by the Ethics Committee of Peking Union Medical College Hospital.
Statistics
Statistical analyses were performed using MedCal Statistical Software (version 13.3.3; Broekstraat, Mariakerke, Beglium). Passing-Bablok regression, Bland-Altman plots, and one-way analysis of variance (ANOVA) with Bonferroni post-hoc analysis were used to compare the 25OHD results of multiple tubes. Paired t-tests were used to compare changes in 25OHD results after storage at different temperatures.
Results
Evaluation of the effects of blood collection tubes
25OHD results for LC-MS/MS were not significantly different in different tubes (P > 0.05). Additionally, the 25OHD results from the Siemens ADVIA Centaur XP system for all tubes correlated well with the 25OHD results of LC-MS/MS (averaged results; correlation coefficient [R] > 0.90). However, significantly higher levels of 25OHD were detected in serum collected in VACUETTE® tubes with serum clot activator and gel than in serum collected using the other three types of tubes on both the Siemens ADVIA Centaur XP system (P < 0.01) and LC-MS/MS (P < 0.01). Bland-Altman tests showed that the overall biases of the 25OHD results for VACUETTE® tubes with serum clot activator and gel between the Siemens ADVIA Centaur XP and LC-MS/MS were high (average: 11.9 [5.7–18.1] ng/mL; Fig 1; conversion: traditional units to SI– 1 ng/mL ≈ 2.5 nmol/L). Repeated ANOVA showed that 25OHD levels in serum collected in VACUETTE® tubes with serum clot activator and gel and analyzed by the Siemens ADVIA Centaur XP system were significantly higher than those determined using LC-MS/MS (P < 0.001) and those determined using the Siemens system for serum collected in the other three types of tubes (P < 0.01; S1 Data).
[Figure omitted. See PDF.]
Fig 1. Comparison of 25OHD results obtained using the Siemens ADVIA Centaur XP system for all types of tubes and those obtained using LC-MS/MS analysis (averaged results).
I–IV are Passing-Bablok regression analyses for the Siemens system (5-mL BD Vacutainer® SST tubes, IMPROVEVACUTER® tubes with serum clot activator and gel, VACUETTE® 4-mL no-additive tubes, and VACUETTE® tubes with serum clot activator and gel, respectively) and 25OHD results from the LC-MS/MS analysis (averaged results). V–VIII are Bland-Altman plots showing the 25OHD bias between the Siemens system using the four types of tubes and LC-MS/MS (averaged results).
https://doi.org/10.1371/journal.pone.0166327.g001
In the additional samples collected from 16 volunteers, we found a similar trend for 25OHD levels in serum collected in VACUETTE® tubes with serum clot activator and gel (S1 Fig, S2 Data). Additionally, 25OHD levels in serum collected in VACUETTE® tubes with clot activator but no gel were 27.1% (1.2–53.0%) higher, on average, than those in serum collected in VACUETTE® 4-mL no-additive tubes (P < 0.01; S2 Data).
Evaluation of the effects of storage temperature
The 25OHD levels in all types of tubes measured using the Siemens ADVIA Centaur XP system did not change significantly after storage at 4°C for 48 h (P > 0.05; Fig 2I). After storage at -80°C for 48 h, the 25OHD levels in samples collected in IMPROVEVACUTER® tubes with serum clot activator and gel analyzed by the Siemens ADVIA Centaur XP system were significantly increased (Fig 2II). However, the correlation between the 25OHD results in IMPROVEVACUTER® tubes with serum clot activator and gel analyzed by the Siemens ADVIA Centaur XP system after storage at -80°C for 48 h and that of serum that analyzed immediately after collection was excellent (R = 0.923; Fig 2III), with a mean bias of 13.1 (5.5–20.6) ng/mL (Bland-Altman tests; P < 0.001 by paired t-tests; Fig 2IV). After storage, the 25OHD levels in serum collected in IMPROVEVACUTER® tubes with serum clot activator and gel correlated well with those in serum collected in VACUETTE® tubes with serum clot activator and gel (R = 0.973; bias: -0.4 [-4.7–3.9] ng/mL; P = 0.450; Fig 2V and 2VI) when measured using the Siemens system. Additionally, 25OHD levels in serum collected in IMPROVEVACUTER® tubes with serum clot activator and gel had a significant bias compared with those in serum collected in 5-mL BD Vacutainer® SST tubes (11.1 [3.9–18.3] ng/mL, P < 0.001) and VACUETTE® 4-mL no-additive tubes (10.9 [2.9–18.9] ng/mL, P < 0.001) when analyzed using the Siemens ADVIA Centaur XP system after storage at -80°C for 48 h (S3 Data).
[Figure omitted. See PDF.]
Fig 2. Effects of storage temperature on the measurement of 25OHD using the Siemens system.
I shows the plot of 25OHD results for samples stored at 4°C for 48 h before measurement. II shows the plot of 25OHD results for samples stored at -80°C for 48 h before measurement; III and IV respectively show the Passing-Bablok regression analysis and Bland-Altman plot for 25OHD results obtained using the Siemens system (IMPROVEVACUTER® tubes with serum clot activator and gel) after storage at -80°C for 48 h and immediately after collection. V and VI respectively show the Passing-Bablok regression analysis and Bland-Altman plot for 25OHD results for the Siemens system using IMPROVEVACUTER® tubes with serum clot activator and gel and VACUETTE® tubes with serum clot activator and gel measured after storage at -80°C for 48 h.
https://doi.org/10.1371/journal.pone.0166327.g002
Discussion
In this study, we compared the effects of different blood collection tubes on 25OHD results obtained using the Siemens ADVIA Centaur XP and found that when serum was collected in either VACUETTE® tubes with clot activator and gel or VACUETTE® tubes with clot activator but no gel, significantly higher values were obtained. Specially, in VACUETTE® tubes with clot activator and gel, 25OHD on the Siemens ADVIA Centaur XP had a mean bias of 111.1% compared with that obtained by LC-MS/MS, which was significantly higher than the reference change value (RCV, 45.5%) based on a within-individual CV (CVI) of 12.1% [3] and the highest analytical imprecision (CVA, 11.1%) provided by Siemens (RCV = 21/2 × Z × (CVA2 + CVI2)1/2, Z score of 1.96 for p < 0.05 [4]). Additionally, after freezing at -80°C, 25OHD in serum collected by IMPROVEVACUTER® tubes showed a clinically significant mean bias of 130.1% (> RCV) compared with the results before freezing
Notably, the clot activator used by most manufacturers is micronized silica; thus, this component is common to most tubes. Additionally, the gel used in the different tubes may be all polyester and unlikely to affect vitamin D results [5]. However, the surfactants used to prevent adhesion of the cells vary, and some surfactants have the potential to interfere with immunoassays [6] because they may affect detachment of antibodies (or antigens) from solid-phase substrates [6–8]. The Siemens ADVIA Centaur assay is a competitive immunoassay using anti-FITC-labeled paramagnetic particles and a FITC-labeled vitamin D analog. Detection occurs via acridium ester (chemiluminescence), with the signal inversely proportional to the amount of vitamin D in the specimen. The label is covalently bound to the particles [9], reducing susceptibility to desorption by a surfactant, and may have led to the unexpected observation of higher 25OHD levels.
The actual 25OHD concentration itself likely did not change during the freeze-thaw process and appeared to be quite stable, even at other temperatures, as previously reported [10]. Additionally, the cryovials should not have interfered as the serum was divided into the same types of cryovials after collection, and 25OHD results in serum collected in blood collection tubes other than IMPROVEVACUTER® did not show significant changes. The most probable explanation is that the composition may have changed in the IMPROVEVACUTER® tubes, resulting in characteristics similar to those of the VACUETTE® tubes and yielding 25OHD values that were increased to almost exactly the same degree as observed in the VACUETTE® tubes with clot activator and gel. Because of the limited amount of serum obtained from the first batch of volunteers was not sufficient for application to multiple analyses, we recruited another 15 volunteers and collected serum samples in IMPROVEVACUTER® tubes. These samples were then separated into three cryovials and analyzed immediately or after storage at 4°C or -80°C for 48 h by LC-MS/MS. However, no significant differences were found among the results (S4 Data).
One limitation of our study was the small sample size; however, based on a power and sample size calculation [11], for a power of 0.95, the calculated sample size was 5. Hence, the sample size used in this study was sufficient to determine the effects of tubes and temperature on 25OHD results obtained using the Siemens ADVIA Centaur XP. Another limitation was that the specific components affecting the results of 25OHD measurement on the Siemens platform were unclear because of the confidentiality maintained by tube manufacturers and Siemens. However, our results strongly suggested that VACUETTE® tubes with additives should not be used on the Siemens system when measuring 25OHD. Additionally, when freezing is included before analysis, IMPROVEVACUTER® tubes should also be avoided.
In conclusion, our results showed that VACUETTE® tubes with additives affected 25OHD results using the Siemens ADVIA Centaur XP system. Moreover, when serum is collected with IMPROVEVACUTER® tubes, freezing will affect the results obtained using the Siemens 25OHD assay platform.
Supporting Information
[Figure omitted. See PDF.]
S1 Data. Original data for comparison of 25OHD results obtained using the Siemens ADVIA Centaur XP system for all types of tubes and those obtained using LC-MS/MS analysis.
https://doi.org/10.1371/journal.pone.0166327.s001
(XLS)
S2 Data. Original data for evaluation of the effects of clot activator and gel on 25OHD using the Siemens ADVIA Centaur XP system.
https://doi.org/10.1371/journal.pone.0166327.s002
(XLS)
S3 Data. Original data for evaluation of the effects of storage temperature on the measurement of 25OHD using the Siemens system.
https://doi.org/10.1371/journal.pone.0166327.s003
(XLS)
S4 Data. Original data for evaluation of the effects of storage temperature on the measurement of 25OHD using the LC-MS/MS system.
https://doi.org/10.1371/journal.pone.0166327.s004
(XLS)
S1 Fig. Evaluation of the effects of clot activator and gel on 25OHD using the Siemens ADVIA Centaur XP system.
https://doi.org/10.1371/journal.pone.0166327.s005
(TIF)
Author Contributions
1. Conceptualization: SY LQ.
2. Data curation: WS.
3. Formal analysis: SY XC HF RZ.
4. Investigation: LX.
5. Methodology: WZ.
6. Project administration: LQ.
7. Software: JH XC.
8. Supervision: LQ.
9. Validation: QC.
10. Writing – original draft: SY.
11. Writing – review & editing: LQ SY.
Citation: Yu S, Zhou W, Cheng X, Fang H, Zhang R, Cheng Q, et al. (2016) Blood Collection Tubes and Storage Temperature Should Be Evaluated when Using the Siemens ADVIA Centaur XP for Measuring 25-Hydroxyvitamin D. PLoS ONE 11(11): e0166327. https://doi.org/10.1371/journal.pone.0166327
1. Ajuria-Morentin I, Mar-Medina C, Bereciartua-Urbieta E, Izquierdo-Quirce F, Valladares-Gomez C, Crespo-Picot E, et al. Lack of transferability between different immunoassays and LC-MS/MS for total 25-hydroxyvitamin D measurement and disagreement defining deficiency. Scand J Clin Lab Invest. 2013; 73(1): 82–86. pmid:23171427
2. Yu S, Cheng X, Fang H, Zhang R, Han J, Qin X, et al. 25OHD analogues and vacuum blood collection tubes dramatically affect the accuracy of automated immunoassays. Sci Rep. 2015; 5: 14636. pmid:26420221
3. Viljoen A, Singh DK, Farrington K, Twomey PJ. Analytical quality goals for 25-vitamin D based on biological variation. J Clin Lab Anal. 2011; 25(2): 130–133. pmid:21438007
4. Fraser CG. Reference change values. Clin Chem Lab Med. 2012; 50(5): 807–812.
5. Tanner M, Kent N, Smith B, Fletcher S, Lewer M. Stability of common biochemical analytes in serum gel tubes subjected to various storage temperatures and times pre-centrifugation. Ann Clin Biochem. 2008; 45(Pt4): 375–379.
6. Stankovic AK, Parmar G. Assay interferences from blood collection tubes: a cautionary note. Clin Chem. 2006; 52(8): 1627–1628. pmid:16873316
7. Bowen RA, Sattayapiwat A, Gounden V, Remaley AT. Blood collection tube-related alterations in analyte concentrations in quality control material and serum specimens. Clin Biochem. 2014; 47(3): 150–157. pmid:24240064
8. Bowen RA, Hortin G.L, Csako G., Otanez OH., Remaley AT. Impact of blood collection devices on clinical chemistry assays. Clin Biochem. 2010; 43(1–2): 24–25.
9. Labonte J. Vitamin D Testing Methods. 2013. Available: http://clinicallaboratoryconsultants.com/lab-tests/vitamin-d-testing-methods/ (accessed April 18, 2016).
10. Antoniucci DM, Black DM, Sellmeyer DE. Serum 25-hydroxyvitamin D is unaffected by multiple freeze-thaw cycles. Clin Chem. 2005; 51(1): 258–261. pmid:15613728
11. Dupont WD, Plummer WD Jr. Power and sample size calculations for studies involving linear regression. Control Clin Trials. 1998; 19(6): 589–601. pmid:9875838
You have requested "on-the-fly" machine translation of selected content from our databases. This functionality is provided solely for your convenience and is in no way intended to replace human translation. Show full disclaimer
Neither ProQuest nor its licensors make any representations or warranties with respect to the translations. The translations are automatically generated "AS IS" and "AS AVAILABLE" and are not retained in our systems. PROQUEST AND ITS LICENSORS SPECIFICALLY DISCLAIM ANY AND ALL EXPRESS OR IMPLIED WARRANTIES, INCLUDING WITHOUT LIMITATION, ANY WARRANTIES FOR AVAILABILITY, ACCURACY, TIMELINESS, COMPLETENESS, NON-INFRINGMENT, MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE. Your use of the translations is subject to all use restrictions contained in your Electronic Products License Agreement and by using the translation functionality you agree to forgo any and all claims against ProQuest or its licensors for your use of the translation functionality and any output derived there from. Hide full disclaimer
© 2016 Yu et al. This is an open access article distributed under the terms of the Creative Commons Attribution License: http://creativecommons.org/licenses/by/4.0/ (the “License”), which permits unrestricted use, distribution, and reproduction in any medium, provided the original author and source are credited. Notwithstanding the ProQuest Terms and Conditions, you may use this content in accordance with the terms of the License.
Abstract
A significant bias was found when using the Siemens ADVIA Centaur XP system for measurement of 25-hydroxyvitamin D (25OHD) with VACUETTE® tubes with Serum Clot Activator and Gel. Here, we examined whether other commonly used tubes or temperatures affected 25OHD results obtained with the Siemens ADVIA Centaur XP system. Serum was collected into five types of vacuum blood collection tubes from three manufacturers, and 25OHD was analyzed using the Siemens ADVIA Centaur XP system and liquid chromatography tandem mass spectrometry (LC-MS/MS) immediately or after storage at 4°C or -80°C for 48 h. Significantly higher 25OHD values were found when using the Siemens ADVIA Centaur XP system with VACUETTE® tubes with serum clot activator and gel and VACUETTE® tubes with clot activator but no gel compared with VACUETTE® tubes with no additives. The 25OHD values in all of these tubes were not significantly different from those obtained by LC-MS/MS. Moreover, after storage at -80°C for 48 h, the values obtained in IMPROVEVACUTER® tubes with serum clot activator and gel significantly increased, with a mean bias of 74.6% compared with the values before storage, on analysis with the Siemens ADVIA Centaur XP system. VACUETTE® tubes containing additives significantly affect the accuracy of 25OHD results obtained using the Siemens ADVIA Centaur XP system. Additionally, the composition of serum collected in IMPROVEVACUTER® tubes was affected by freezing, resulting in different measurements when using the Siemens 25OHD assay platform.
You have requested "on-the-fly" machine translation of selected content from our databases. This functionality is provided solely for your convenience and is in no way intended to replace human translation. Show full disclaimer
Neither ProQuest nor its licensors make any representations or warranties with respect to the translations. The translations are automatically generated "AS IS" and "AS AVAILABLE" and are not retained in our systems. PROQUEST AND ITS LICENSORS SPECIFICALLY DISCLAIM ANY AND ALL EXPRESS OR IMPLIED WARRANTIES, INCLUDING WITHOUT LIMITATION, ANY WARRANTIES FOR AVAILABILITY, ACCURACY, TIMELINESS, COMPLETENESS, NON-INFRINGMENT, MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE. Your use of the translations is subject to all use restrictions contained in your Electronic Products License Agreement and by using the translation functionality you agree to forgo any and all claims against ProQuest or its licensors for your use of the translation functionality and any output derived there from. Hide full disclaimer